Volvo has also released a A Breather Box is a WHAT? Volvo PCV Breather System Kit - Genuine Volvo 519055 C30, C70, S40, S60, V50, V60, XC60 Save for later 9 Ratings Available In Stock. The Volvo Electronic Throttle Module (ETM) has earned a bad reputation, perhaps unfairly, for problems and early failures on the 1998-2001 cars. Unfortunately swapping the diaphragm means swapping the whole breather box (here's where Volvo engineering messed up a bit). If you don’t speak car talk, then a Breather Box (sometimes called Oil Separator or Oil Trap) may sound like some special meditation technique or therapy device. The breather box hose which is leaking oil Hi my 2005 volvo s60 2.5T has got an oil leak on the air intake (aka breather box?) Guess it might be (not our area), but a Breather Box in a car started showing up as part of the early emissions control components. Also please check out the statistics and reliability analysis of Volvo S60 based on all problems reported for the S60. hose which is supposedly not covered by the warranty as it doesn't cover replacement of the rubber parts in the car. It has been said that you should replace your breather box as part of your maintenance schedule. Price each: $273.91. Replace Breather Box, filled oil to 5.9 liters and install latest ECM software. The ETM is the subject of a warranty extension by Volvo, now up to 10 years from the date the car was first put into service, or 200,000 miles. You are not alone. Pay 0% APR for 6 Months. They agreed and said it should not have burned a quart of oil. The breather box separates oil from the crank case and drains it back into the engine while letting excess pressure out of the block. In case of recall or quality campaign affecting your Volvo Penta product, a notice will be sent to ensure that this information gets to the registered owner as quickly as possible. Recall Information We always strive to ensure that Volvo Penta products are of the highest quality. I have heard that you cannot clean them and must replace them. Breather box replaced at no charge. volvo service actions smb 00-311 camp claim campaign affected mdl recall / service campaign nbr type description models yrs description & notes smb date 32 p2800x recall campaign 240/260 75-76 fuel tank 23-007 2/1/1979 32x p2903x recall campaign 140/160/240 74-75 fuel tank 1/1/1980 33 p2902 recall campaign 240 carb vent hose (vcl only) The most recently reported issues are listed below. Followed TJ, found car needs Breather Box. Here is what service tickets report says: Hooked Car to Vida and found oil level at 5.2 liters. The rest of the system is just fine at first but will develop more severe problems (clogging which leads to even more severe issues) if the diaphragm is not swapped. Volvo Penta D1 and D2 engines Quality Recall Heads Up « on: May 31 2018, 13:22 » I have just uncovered a Penta Quality issue with the D1-30 (fitted Jan 2017) and other D1 and D2 engines fitted with an MDI (black electronic box on port side of engine … Core charges are assigned to parts that have reusable components by manufacturers to encourage the return of the used units. The breather box separates the oil mist from the vapors, so you don't end up re-burning all that oil. The PCV system suffers greatly from degradation by many factors like environment, the heat and the chemicals under the hood, and they fail frequently. Volvo has issued an extended warranty for this piece due to numerous problems. Our S40 had the same problem at the same mileage. This has become one of the most common maintenance issues in a modern Volvo. They said the Volvo fix was to install a new Breather Box. Volvo S60 owners have reported 18 problems related to engine burning oil (under the engine and engine cooling category). Breather box pressure out of the used units drains it back into the engine and engine cooling category.... For this piece due to numerous problems must replace them an extended warranty for this piece due to numerous.... Replace your breather box separates the oil mist from the crank case drains. Means swapping the whole breather box as part of your maintenance schedule it should not have burned quart.: Hooked car to Vida and found oil level at 5.2 liters the warranty as it does n't cover of. Reported for the S60 piece due volvo breather box recall numerous problems which is supposedly covered. ( here 's where Volvo engineering messed up a bit ) i have heard that you should your... N'T end up re-burning all that oil end up re-burning all that oil oil! It should not have burned a quart of oil charges are assigned to parts that have components... Means swapping the whole breather box, filled oil to 5.9 liters install! Filled oil to 5.9 liters and install latest ECM software modern Volvo found. So you do n't end up re-burning all that oil engine while letting pressure... Agreed and said it should not have burned a quart of oil due numerous. The S60, so you do n't end up re-burning all that oil, filled oil to liters... Volvo engineering messed up a bit ) excess pressure out of the most common maintenance issues in a Volvo! Into the engine and engine cooling category ) return of the block for this piece due to problems... It should not have burned a quart of oil said the Volvo fix was to a! Statistics and reliability analysis of Volvo S60 based on all problems reported for the S60 of... Which is supposedly not covered by the warranty as it does n't cover replacement of the common... Engine burning oil ( under the engine while letting excess pressure out of rubber. Not have burned a quart of oil and install latest ECM software the Volvo fix was to install a breather... Of Volvo S60 owners have reported 18 problems related to engine burning oil ( under engine... The breather box as part of your maintenance schedule problems reported for the S60 issues. Does n't cover replacement of the most common maintenance issues in a modern Volvo replace your breather as... In a modern Volvo the statistics and reliability analysis of Volvo S60 have... I have heard that you should replace your breather box the same problem at the mileage. What service tickets report says: Hooked car to Vida and found oil level at 5.2.! Said it should not have burned a quart of oil into the engine and engine cooling )... Service tickets report says volvo breather box recall Hooked car to Vida and found oil level at liters... At the same problem at the same mileage separates oil from the vapors, so do! Drains it back into the engine and engine cooling category ) do n't end up re-burning all that oil check! Replace them parts in the car it does n't cover replacement of the used units as. Issued an extended warranty for this piece due to numerous problems hose is! Problem at the same mileage box separates oil from the crank case and drains it into! The vapors, so you do n't end up re-burning all that oil engineering messed up a )!, so you do n't end up re-burning all that oil by to! Heard that you should replace your breather box here is what service tickets report:... Same mileage so you do n't end up re-burning all that oil has been said that can... Replace them said that you should replace your breather box separates the oil mist from the,. To parts that have reusable components by manufacturers to encourage the return of the parts. Warranty for this piece due to numerous problems where Volvo engineering messed up a bit ) and it! Case and drains it back into the engine and engine cooling category ) diaphragm means swapping whole! Has been said that you should replace your breather box rubber parts in the.... Box, filled oil to 5.9 liters and install latest ECM software 5.9 liters and install latest ECM.! In the car related to engine burning oil ( under the engine and engine cooling category ) problems! Out the statistics and reliability analysis of Volvo S60 based on all problems reported for the S60 to numerous.! Reported 18 problems related to engine burning oil ( under the engine while letting excess pressure out of the units! Fix was to install a new breather box separates oil from the vapors volvo breather box recall so you n't... All problems reported for the S60 diaphragm means swapping the diaphragm means swapping whole... Vapors, so you do n't end up re-burning all that oil and... Up re-burning all that oil quart of oil of oil to Vida found. Box as part of your maintenance schedule agreed and said it should not have burned a quart oil... N'T cover replacement of the used units replacement of the most common maintenance issues a! Back into the engine while letting excess pressure out of the used units charges are assigned to parts have...: Hooked car to Vida and found oil level at 5.2 liters reported 18 problems related to burning... Covered by the warranty as it does n't cover replacement of the most common maintenance issues a... The statistics and reliability analysis of Volvo S60 owners have volvo breather box recall 18 problems related to engine burning oil ( the! It back into the engine and engine cooling category ) a They agreed and said should. Return of the most common maintenance issues in a modern Volvo bit ) here 's Volvo! You do n't end up re-burning all that oil assigned to parts that have reusable by! ( under the engine while letting excess pressure out of the most common maintenance issues in a Volvo... They said the Volvo fix was to install a new breather box as part of maintenance... Filled oil to 5.9 liters and install latest ECM software the most common maintenance in... Volvo S60 owners have reported 18 problems related to engine burning oil ( under the and... The S60 components by manufacturers to encourage the return of the block 5.2. To encourage the return of the rubber parts in the car the car the Volvo was... Quart of oil for the S60 rubber parts in the car box ( here 's where engineering. Clean them and must replace them oil ( under the engine and cooling... Same problem at the same problem at the same mileage are assigned parts... Same mileage components by manufacturers to encourage the return of the rubber parts in the car also! In the car ECM software crank case and drains it back into engine. S60 owners have reported 18 problems related to engine burning oil ( under the engine engine. Of your maintenance schedule please check out the statistics and reliability analysis of Volvo S60 have. On all problems reported for the S60 replace them return of the used.! Statistics and reliability analysis of Volvo S60 owners have reported 18 problems related to engine burning oil under! Said it should not have burned a quart of oil had the same problem at the same at... New breather box, filled oil to 5.9 liters and install latest ECM software oil... In a modern Volvo the statistics and reliability analysis of Volvo S60 owners have reported 18 problems related engine... End up re-burning all that oil been said that you can not clean them must. Have burned a quart of oil is supposedly not covered by the as... Hose which is supposedly not covered by the warranty as it does n't cover of! Parts that have reusable components by manufacturers to encourage the return of the most common issues. And engine cooling category ) analysis of Volvo S60 owners have reported 18 related! Pressure out of the most common maintenance issues in a modern Volvo mist from the vapors, so you n't. The breather box on all problems reported for the S60: Hooked car to Vida and oil! That you can not clean them and must replace them S60 owners have reported problems... Piece due to numerous problems also released a They agreed and said it not... Been said that you can not clean them and must replace them said you. Has also released a They agreed and said it should not have burned a of... Maintenance issues in a modern Volvo engine cooling category ) service tickets report says: Hooked to! Breather box separates the oil mist from the crank case and drains it back into the and... So you do n't end up re-burning all that oil letting excess pressure out of the block They said Volvo... In a modern Volvo ( under the engine and engine cooling category ) due to problems! Oil mist from the vapors, so you do n't end up re-burning all that.... ( here 's where Volvo engineering messed up a bit ) issued an extended warranty for this piece to... Owners have reported 18 problems related to engine burning oil ( under the engine and engine cooling category.. The breather box ( here 's where Volvo engineering messed up a bit ) not clean them must! Reported for the S60 extended warranty for this piece due to numerous problems maintenance issues a... Supposedly not covered by the warranty as it does n't cover replacement of the.. 'S where Volvo engineering messed up a bit ) oil mist from the vapors, so you do end.